Product ID:CP-70 CHIL-JOINT (R)
MSDS Date:01/01/1990
FSC:8030
NIIN:00N016348
MSDS Number: BKMWJ

CHILDERS PRODUCTS CO

2061 HARTEL
LEVITTOWN, PA 19057
US

Emergency Phone: 215-943-7600;800-424-9300(CHEMTREC)

Info Phone: 215-943-7600

Preparer: ROBERT ANDREWS

Cage: 3K675

CHILDERS PRODUCTS CO INC

BRISTOL, PA 19007-0505 US

Cage: 3K675

STODDARD SOLVENT

CAS: 8052-41-3

RTECS: WJ8925000

Fraction By Weight: 1-4%

OSHA PEL 500 PPM

ACGIH TLV: 100 PPM; 9293

CALCIUM CARBONATE (MARBLE) (LIMESTONE)

CAS: 1317-65-3

RTECS: EV9580000

Fraction By Weight: 65-70%

OSHA PEL 15 MG/M3 TDUST

ACGIH TLV: 10 MG/M3 TDUST; 9192

POLYMERIZED LINSEED OIL

CAS: 67746-08-1

BUTENE, POLYMERS (POLYBUTENE)

CAS: 9003-29-6

RTECS: EM9032000

SILICA, CRYSTALLINE - QUARTZ

CAS: 14808-60-7

RTECS: VV7330000

Fraction By Weight: <1%

OSHA PEL SEE TABLE Z3

ACGIH TLV: 0.1 MG/M3 RDUST;9293

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE:NONE EXPECTED. CHRONIC:PROLONGED
EXPOSURE TO VAPORS MAY BE SLIGHTLY IRRITATING TO MUCOUS MEMBRANES.
EYE: MAY BE AN IRRITANT. SKIN: MAY CAUSE IRRITATION UPON PROLONGED
OR REPEATED CONTACT. INHAL: PROLONGED EXPOSURE TO VAPORS MAY
SLIGHTLY IRRITATING TO MUCOUS MEMBRANES. INGEST: MAY RESULT IN (SEE
EFTS OF OVEREXP)
Explanation of Carcinogenicity:CALCIUM CARBONATE: CONTAINS <1%
CRYSTALLINE SILICA-NOT RESPIRABLE IN THIS PRODUCT.
Effects of Overexposure:HLTH HAZ: VOMITING; ASPIRATION OF LIQUID INTO
LUNGS MUST BE AVOIDED AS LIQUID CONTACT W/LUNGS CAN RESULT IN
CHEMICAL PNEUMONITIS AND PULMONARY EDEMA/HEMORRHAGE.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.

First Aid:EYE:FLUSH THORO W/WATER FOR AT LEAST 15 MINS. CONSULT MD IF
IRRIT PERSISTS. SKIN:WASH THORO W/SOAP & WATER. INHAL:IF BRTHG
DIFFICULTIES, DIZZ OR LIGHTHEADEDNESS OCCUR WHEN WORKING IN AREAS
W/HIGH VAP CONC, VICTIM SHOULD SEEK AIR FREE OF VAPS. IF VICTIM
EXPERIENCES CONTINUED BRTHG DIFFICULTIES, ADMINISTER O*2 UNTIL MED
ASSISTANCE CAN BE RENDERED. IF BRTHG STOPS, BEGIN ARTF RESP (SEE
SUPP DATA)

Flash Point:150
Lower Limits:0.9%
Upper Limits:6.0%
Extinguishing Media:FOAM, CO*2, OR DRY CHEMICAL, NO WATER.
Fire Fighting Procedures:NIOSH/MSHA APPRVD SCBA AND FULL PROT EQUIP .
H2*O MAY BE UNSUITABLE AS AN EXTING MEDIA/BUT HELPFUL IN KEEPING
CONTR COOL.
Unusual Fire/Explosion Hazard:KEEP WORK AREAS FREE OF HOT METAL AND
OTHER SOURCES IF IGNITION.

Spill Release Procedures:KEEP SOURCES OF IGNITION AND HOT METAL
SURFACES ISOLATED FROM THE SPILL. SCRAPE MATERIAL INTO CONTAINER
FOR DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:KEEP TIGHTLY CLOSED IN COOL, DRY,
VENTILATED AREA. PROTECT FROM STATIC DISCHARGE.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.

Respiratory Protection:THE USE OF RESP PROT IS ADVISED WHEN CONC EXCEED
THE ESTABLISHED EXPOS LIMITS. DEPENDING ON THE MEASURED AIRBORNE
CONC, USE A NIOSH/MSHA APPROVED RESP OR GAS MASK W/APPROP
CARTRIDGES AND CANISTERS OR SUPPLIED AIR EQUIPMENT.
Ventilation:GEN MECH VENT MAY BE SUFFICIENT TO KEEP PROD VAP CONC W/IN
TIMEWEIGHTED TLV RANGES. IF GEN VENT PROVES (SEE SUPP DATA)
Protective Gloves:IMPERMEABLE GLOVES RECOMMENDED.
Eye Protection:CHEM WORK GOGGS, MAY ADD (SEE SUPP DATA)
Other Protective Equipment:EYE WASHES, SAFETY SHOWERS & IMPERMEABLE
APRONS.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
FIRST AID PROC:& SEEK IMMED MED ATTN. INGEST:DO NOT INDUCE VOMITING.
SEEK IMMED MED ADVICE/ATTN. VENT:INADEQUATE TO MAINTAIN SAFE VAP
CONC, SUPPLEMENTAL LOCAL EXHAUST MAY BE REQUIRED. OTHER SPEC PRECA
UTIONS SUCH AS RESP OR ENVIRONMENTAL DEVICES MAY BE REQD IN EXTREME
CASES. EYE PROT:FULL LENGTH FSHLD TO GOGGLES .

HCC:V4
Boiling Pt:B.P. Text:250F,121C
Spec Gravity:1.6
Evaporation Rate & Reference:4.4 (ETHER=1)
Solubility in Water:NEGLIGIBLE.
Appearance and Odor:GRAY CAULK, RESINOUS ODOR.
Percent Volatiles by Volume:2

Stability Indicator/Materials to Avoid:YES
INCOMPATIBLE W/STRONG OXIDIZING AGENTS, STRONG ACIDS & BASES, AND
SELECTED AMINES.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:CARBON MONOXIDE AND/OR CARBON DIOXIDE.

Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH ALL APPLICABLE
REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.